Muhammad Ihsan
Department of Chemical Engineering, Faculty of Engineering, Universitas Al-Khairiyah, Cilegon, Indonesia

Tiyana Ramadhini Az Zahra
Department of Chemical Engineering, Faculty of Engineering, Universitas Al-Khairiyah, Cilegon, Indonesia

Hana Pertiwi
Department of Chemical Engineering, Faculty of Engineering, Universitas Al-Khairiyah, Cilegon, Indonesia

Devi Lestariningsih
Department of Chemical Engineering, Faculty of Engineering, Universitas Al-Khairiyah, Cilegon, Indonesia

DOI: https://doi.org/10.19184/jobc.v6i1.60004

ABSTRACT
Soapberry fruit contains natural saponins with potential as biosurfactant active ingredients in liquid hand soap formulations. This study aimed to formulate and evaluate the physical quality of a liquid hand soap based on soapberry fruit extract, with sodium chloride (NaCl) employed as a viscosity regulator instead of conventional carboxymethyl cellulose (CMC). Formulations were prepared at soapberry extract concentrations of 20% (F1), 25% (F2), and 30% (F3) using Virgin Coconut Oil (VCO) and potassium hydroxide (KOH) via saponification. Physical quality was evaluated through organoleptic assessment and pH measurement in accordance with SNI 2588:2017, supplemented by foam stability and specific gravity as additional physicochemical parameters. All formulations satisfied the SNI 2588:2017 pH requirement (4–10), yielding pH 8 across all extract-containing formulations, while specific gravity ranged from 1.031 to 1.038 g/mL. Foam stability decreased progressively with increasing extract concentration (87.5%, 85.8%, and 84.6% for F1, F2, and F3, respectively). F1 was selected as the optimal base formulation based on its superior foam stability and lowest specific gravity at the minimum effective extract concentration. Betel leaf essential oil was subsequently incorporated into F1 at 0.5%, 1%, and 2%, and antibacterial activity against Escherichia coli was assessed using the disk diffusion method. Inhibition zones of 23.8, 24.2, and 33.0 mm were recorded at 0.5%, 1%, and 2%, respectively, all classified as very strong antibacterial activity. The combination of 20% soapberry extract (F1) with 2% betel leaf essential oil was identified as the most optimal formulation.

Keywords: soapberry fruit, hand soap, saponin, betel leaf, antibacterial, NaCl viscosity regulator

REFERENCES

[1]  Okombi, S.L., Gillaizeau, F., Leuillet, S., et al., Effect of Sodium Lauryl Sulfate (SLS) Applied as a Patch on Human Skin Physiology and Its Microbiota, Cosmetics 8(1) (2021) 6. https://doi.org/10.3390/cosmetics8010006

[2]  Adu, S.A., Twigg, M.S., Naughton, P.J., et al., Characterization of cytotoxicity and immunomodulatory effects of glycolipid biosurfactants on human keratinocytes, Applied Microbiology and Biotechnology 107(1) (2022) 389–404. https://doi.org/10.1007/s00253-022-12302-5

[3]  Pratiwi, R.A., Zuhri, M., & Oktaviani, I., How can the world overlook Soapberry bioprospection? A niche for Indonesia, BIOTROPIA 31(1) (2024) 10–22. https://doi.org/10.11598/btb.2024.31.1.1926

[4]  Putri, D.C.A., Putri, N.P.A., & Listyawati, M.B., Potensi Pengembangan Lerak (Soapberry) Sebagai Bahan Bermanfaat di Bidang Farmasi, Jurnal Farmasi Galenika 10(2) (2023) 124–133. https://doi.org/10.70410/jfg.v10i2.283

[5]  Sari, R.I.P., Ardinata, N., Hermansyah, O., et al., Testing the activity and formulation of natural hand soap based on natural surfactant of lerak fruit (Soapberry DC.) against Staphylococcus aureus, Medical Sains: Jurnal Ilmiah Kefarmasian 9(1) (2024) 347–354. https://doi.org/10.37874/ms.v9i1.1151

[6]  Hawa, L.C., Nada, U.Q., & Sumarlan, S.H. Karakteristik sifat fisikokimia sabun cuci cair menggunakan sari lerak sebagai surfaktan alami. Agrointek: Jurnal Teknologi Industri Pertanian 17(1) (2023) 213–223. https://doi.org/10.21107/agrointek.v17i1.

[7]  10696Ruengvisesh, S., Wenbap, P., Damrongsaktrakul, P., et al., Essential Oil Extraction of Betel leaf, Piper ramipilum, and Piper aduncum and their Antibacterial Activity against Food-borne Pathogens, Journal of Essential Oil Bearing Plants 26(2) (2023) 446–458. https://doi.org/10.1080/0972060X.2023.

[8]  2202335Mustam, M., Hasanah, N., & Safitri, L., Aktivitas antibakteri minyak atsiri daun sirih (Betel leaf L.), Jurnal Farmasi Indonesia 19(1) (2022) 12–18.

[9]  Ariyani Agustina, N., & Piska, F., Karakteristik fisik sabun organik berbasis minyak jelantah dan ekstrak b) dengan biosurfuah pinang (Arecaktan buah leraka catechu L. (Soapberry DC), Stannum: Jurnal Sains dan Terapan Kimia 7(1) (2023).

[10]  Wijayanti, F., Sari, M., Suprayitno, R., & Aminin, D., The gel soap with raw materials of lerak fruit (Soapberry DC), Stannum: Jurnal Sains dan Terapan Kimia 2(1) (2020) 1–6. https://doi.org/10.33019/jstk.v2i1.1618

[11]  Wijaya, M.A., & Cahyanti, N.D., Pengaruh pH sabun cair Virgin Coconut Oil (VCO) terhadap aktivitas antibakteri Staphylococcus aureus, Journal of Health Science and Technology 6(1) (2025) 52–61.

[12]  Y. Usman and M. Baharuddin, "Uji Stabilitas dan Aktivitas Sabun Mandi Cair Ekstrak
Etanol Daun Alpukat (Persea americana Mill.)," Jurnal MIPA, 12(2) (2023) 43–49.

[13]  Mardiah, H.D., Evaluasi fisikokimia formula sabun cair pembersih tangan dengan kandungan ekstrak etanol daun petai Cina (Leucaena leucocephala), Skripsi, UIN Maulana Malik Ibrahim Malang (2023).

[14]  F. O. Nitbani, P. J. P. Tjitda, F. Nitti, J. Jumina, and A. I. R. Detha, “Antimicrobial properties of lauric acid and monolaurin in virgin coconut oil: A review,” ChemBioEng Reviews, vol. 9, pp. 442–461, 2022, https://doi.org/10.1002/cben.202100050

[15]  S. W. Tan, B. K. Yoon, and J. A. Jackman, “Membrane-disruptive effects of fatty acid and monoglyceride mitigants on E. coli bacteria-derived tethered lipid bilayers,” Molecules, vol. 29, no. 1, p. 237, 2024, https://doi.org/10.3390/molecules29010237

[16]  Guo, X., Li, J., Chen, W., et al., Chloroxylenol at environmental concentrations can promote conjugative transfer of antibiotic resistance genes by multiple mechanisms, Science of The Total Environment 808 (2022) 151941. https://doi.org/10.1016/j.scitotenv.2021.151941

[17]  Olaru, I.D., Schoeler, S., & Schaumburg, F., The impact of agar depth on antimicrobial susceptibility testing by disc diffusion, Journal of Medical Microbiology 73(9) (2024). https://doi.org/10.1099/jmm.0.001890

[18]  Antimicrobials Discovery Review Group, Beyond One-Size-Fits-All: Addressing Methodological Constraints in Novel Antimicrobials Discovery, Antibiotics 14(8) (2025) 848. https://doi.org/10.3390/antibiotics14080848

[19]  Gajic, I., Kabic, J., Kekic, D., Jovicevic, M., Milenkovic, M., Mitic Culafic, D., Trudic, A., Ranin, L., & Opavski, N., Antimicrobial Susceptibility Testing: A Comprehensive Review of Currently Used Methods, Antibiotics 11(4) (2022) 427. https://doi.org/10.3390/antibiotics11040427

[20] Bovo, F., Lazzarotto, T., Ambretti, S., & Gaibani, P., Comparison of Broth Microdilution, Disk Diffusion and Strip Test Methods for Antimicrobial Susceptibility Testing, Antibiotics 12(3) (2023) 614. https://doi.org/10.3390/antibiotics12030614